Correction to This Article
A previous version of this article misstated the former affiliation of James Oberg. He worked at NASA mission control as a private contractor, not a NASA employee. In addition, the article said that the number of Soyuz spacecraft under order from a Russian company has recently doubled to 10 annually. The doubled order includes Soyuz crew transports and Progress cargo ships.

Perilous Landings by Soyuz Worry NASA

Members of the ground crew check the area around the Soyuz capsule. The three astronauts on board, including American Peggy A. Whitson, were uninjured.
Members of the ground crew check the area around the Soyuz capsule. The three astronauts on board, including American Peggy A. Whitson, were uninjured. (By Shamil Zhumatov -- Associated Press)
By Marc Kaufman
Washington Post Staff Writer
Monday, May 12, 2008

Two consecutive chaotic and dangerous landings by Soyuz space capsules, including one with an American astronaut aboard, have NASA and space experts concerned about the spacecraft's reliability in ferrying astronauts to and from the international space station.

The worries are compounded by the fact that starting in 2010, when the space shuttle fleet will be retired, the United States will be entirely dependent on Russia's Soyuz capsules and rockets for transporting all astronauts and most cargo to the station -- until at least 2015.

The Soyuz has been a remarkably safe and reliable spacecraft for four decades, and the recent failures do not appear to have anything to do with new technology or new procedures. Rather, the two very similar reentry failures point to malfunctioning parts or faulty workmanship, space experts say.

"These are the same kinds of warning signs that occurred on the shuttles before the Columbia accident but were ignored," said James Oberg, a former NASA mission control specialist and now a media consultant on NASA developments. He recently wrote an article on the Soyuz problem for the magazine IEEE Spectrum based on, among other sources, internal NASA documents related to Soyuz.

"We're asking a lot of the Russians -- a doubling of their Soyuz production -- and we may well be overstraining their capacity," he said.

The Russian space agency is conducting an investigation into the failures that is supposed to be completed before the next Soyuz flight in the fall. But some are concerned that the inquiry into the first failure apparently came to the wrong conclusion about what caused the capsule to plunge to a ballistic landing that greatly increased the gravitational forces on, and danger to, the three astronauts aboard.

Sen. Bill Nelson (D-Fla.) has asked NASA whether Americans will be on the investigative commission and, if not, whether they can be added. Nelson said he has not yet received an answer.

"This is very worrisome, and makes it all the more important to get new American spacecraft ready to fly sooner than 2015," he said. Nelson and his colleagues in the House and Senate have sought an additional $2 billion over two years to speed design and production of NASA's new Orion and Ares systems -- which are being built to service the space station and carry astronauts to the moon and beyond-- but the White House has not supported the additional spending.

Adding to the concern, three usually dependable Russian Proton rockets, used to send satellites into orbit, have also failed in the past two years.

The most recent Soyuz emergency landing occurred April 19, nearly 300 miles from the intended landing site in Kazakhstan, and may have been caused by the failure of a bolt connecting the Soyuz capsule and an equipment module, causing it to disconnect improperly, Russian and American officials have said. A steep and very rough ballistic landing followed, reportedly subjecting the astronauts to more than eight times the force of gravity, almost twice the G-forces in a normal landing.

None of the astronauts was injured, including American Peggy A. Whitson, who was returning after six months of weightlessness on the space station. But the spacecraft lost communication during reentry and remained out of radio contact with Russian mission control for an hour, raising the specter of a crash landing.

NASA has emphasized the admirable safety record of the Soyuz system. Nonetheless, NASA's associate administrator for space operations, William H. Gerstenmaier, has said that no more Americans will fly on Soyuz until the problem is identified and fixed. Gerstenmaier, who was at the landing site in April and anxiously waited the hour before the crew contacted mission control on an emergency satellite phone, said the Russians were taking the investigation "very seriously."

CONTINUED     1        >

© 2008 The Washington Post Company